Can you MOT my Vivaro?

If it is plated at up to 3,000kg, yes, as it will be Class 4. Many Vivaros fall into that bracket, but some are plated heavier and need a Class 7 MOT, which we do not do. The weight is on the plate in the door pillar. Call 0121 544 3736 with your registration if you want us to check.

Why does my Vivaro judder when pulling away?

A judder from a standstill usually points to a worn clutch or a failing dual-mass flywheel, especially on older Vivaro A vans that have done high miles. A rattle at idle that stops when you press the clutch is another sign. We road test the van and tell you exactly what is worn.

What does an AdBlue warning mean on a Vivaro C?

It may just mean the tank needs filling. If the tank is full and the warning stays, there is likely a fault in the pump, heater, sensor or doser. The van can count down to a no-start if it is not fixed. We read the codes and test the system to find the cause.

Why does my Vivaro keep blocking its DPF?

The DPF cleans itself on longer runs at steady speed. Vans doing short local work rarely get that chance, so soot builds up. Sensor faults, EGR problems and the wrong oil can make it worse. We find out what is going on and advise whether a regeneration, clean or replacement is right.

Is the Vivaro the same as the Renault Trafic?

The Vivaro A and B were built alongside the Renault Trafic and share a lot with it, including the engines. The Vivaro C is based on a different platform, shared with the Peugeot Expert and Citroen Dispatch. That matters for parts and faults, and we work on all of them.

Do you work on the Combo and Movano?

Yes. We service and repair the Combo and Movano as well as the Vivaro. The Combo is a small van and always Class 4, so we can MOT it here. Most Movanos are plated at 3.5 tonnes and need a Class 7 test elsewhere, but we can service, repair and prepare them.

Will using you affect my Vauxhall warranty?

No. Block exemption rules let an independent garage service your van without affecting the manufacturer warranty, as long as the work follows the schedule and uses parts and oils to the right specification. We do both and record every service.

How do I book my Vivaro in?

Call us on 0121 544 3736 or drop in to 93 Park Lane, Oldbury, B69 4LP. We are open Monday to Friday, 8:30am to 5:30pm. Let us know your registration and what the van is doing, and we will give you a clear quote before we start.

RH Auto Engineering

Vauxhall Vivaro Servicing & Repairs Oldbury

We service and repair Vauxhall Vivaros of every generation in Oldbury, plus the Combo and Movano, with a clear price before any work.

Why book with us

Vauxhall Vivaro Servicing & Repairs Oldbury with clear advice.

The Vivaro is one of the most common mid-size vans on the road, and there are plenty working around Oldbury. Tradespeople like them for their load space and running costs. We service and repair all three generations at our workshop: the original Vivaro A, the Vivaro B from 2014 and the current Vivaro C. We also look after the smaller Combo and the larger Movano, following Vauxhall's schedule and using the right oils and parts.

Each Vivaro generation has its own habits. Older Vivaro A vans often need clutches and dual-mass flywheels, and can suffer injector and EGR faults. The Vivaro B with the 1.6 diesel can block its DPF and EGR on short local work. The Vivaro C uses AdBlue to cut emissions, and faults in the AdBlue system can bring on warnings and a countdown to a no-start. We know these vans and check for these faults.

A van off the road is lost income, so we keep things straightforward. We find the fault, tell you what is urgent and what can wait, and give you a written quote. Nothing is done without your approval. We use oils made to the right specification, including low-ash oil for DPF-equipped vans, and under block exemption rules a service with us keeps your warranty valid.

We are a DVSA-approved Class 4 MOT centre, covering vans up to 3,000kg design gross weight. Many Vivaros are plated at or under 3,000kg, and every Combo is Class 4, so we can test them here. Some Vivaros are plated heavier, and most Movanos are 3.5 tonnes, which means a Class 7 MOT that we do not do. We still service and repair those vans and can do a pre-MOT check.

We are a family business and have looked after vehicles in Oldbury since 1991, for drivers and businesses in West Bromwich, Rowley Regis, Smethwick and Halesowen too. We are open Monday to Friday, 8:30am to 5:30pm, at 93 Park Lane, Oldbury, B69 4LP, and you are welcome to drop in and talk to us. To book your Vivaro in, call us on 0121 544 3736 with the registration.

Vivaro A, B and C

Every Vivaro generation, plus the Combo and Movano.

Clutch and flywheel work

Worn clutches and dual-mass flywheels replaced.

DPF and EGR faults

Found with diagnostics and fixed at the cause.

AdBlue on newer vans

Pumps, heaters and sensors tested before anything is replaced.

Right oils and parts

Correct-spec oils protect your DPF and keep your warranty valid.

Class 4 MOTs

Combos and Vivaros up to 3,000kg tested here.

Common Vauxhall models

Known faults we fix on Vauxhalls

The problems we see most on these models, and what you will notice first.

Vauxhall Vivaro A

2001–2014, 1.9 CDTI, 2.0 CDTI, 2.5 CDTI

Clutch and dual-mass flywheel wearJudder when moving off, slipping under load and a rattle at idle.
Injector faultsRough idle, smoke, hard starting and a loss of power.
EGR valve problemsEngine warning light, hesitation and poor pulling.

Vauxhall Vivaro B

2014–2019, 1.6 CDTI, 1.6 BiTurbo CDTI

DPF blockingDPF warning and limp mode on vans that mostly do short trips.
EGR faultsEngine light, flat spots and reduced power.

Vauxhall Vivaro C

2019 onwards, 1.5 and 2.0 diesel

AdBlue system faultsAdBlue warnings and a countdown to a no-start, even with fluid in the tank.
DPF blockingDPF light and a loss of power on short-run vans.

Vauxhall Combo E

2018 onwards, 1.5 diesel, 1.6 diesel

AdBlue system faultsAdBlue warnings and engine lights, even with the tank full.
DPF blockingDPF warning and reduced power on vans used for short local drops.

Vauxhall Vivaro Servicing & Repairs Oldbury

What we do on Vauxhall Vivaros

Clear expectations, no surprises. If anything extra is needed, we explain it first.

Servicing to Vauxhall's schedule with your service record updated.
Diagnostic scans for warning lights, limp mode and running faults.
Clutch and dual-mass flywheel replacement.
DPF diagnosis, regeneration, cleaning and replacement.
EGR valve diagnosis and repair.
AdBlue system faults on the Vivaro C and newer Combo.
Injector testing and fuel system repairs.
Brakes, suspension and steering work.
Class 4 MOTs for Combos and Vivaros up to 3,000kg.

Vauxhall Vivaro Servicing & Repairs Oldbury

Common questions

Can you MOT my Vivaro?: If it is plated at up to 3,000kg, yes, as it will be Class 4. Many Vivaros fall into that bracket, but some are plated heavier and need a Class 7 MOT, which we do not do. The weight is on the plate in the door pillar. Call 0121 544 3736 with your registration if you want us to check.
Why does my Vivaro judder when pulling away?: A judder from a standstill usually points to a worn clutch or a failing dual-mass flywheel, especially on older Vivaro A vans that have done high miles. A rattle at idle that stops when you press the clutch is another sign. We road test the van and tell you exactly what is worn.
What does an AdBlue warning mean on a Vivaro C?: It may just mean the tank needs filling. If the tank is full and the warning stays, there is likely a fault in the pump, heater, sensor or doser. The van can count down to a no-start if it is not fixed. We read the codes and test the system to find the cause.
Why does my Vivaro keep blocking its DPF?: The DPF cleans itself on longer runs at steady speed. Vans doing short local work rarely get that chance, so soot builds up. Sensor faults, EGR problems and the wrong oil can make it worse. We find out what is going on and advise whether a regeneration, clean or replacement is right.
Is the Vivaro the same as the Renault Trafic?: The Vivaro A and B were built alongside the Renault Trafic and share a lot with it, including the engines. The Vivaro C is based on a different platform, shared with the Peugeot Expert and Citroen Dispatch. That matters for parts and faults, and we work on all of them.
Do you work on the Combo and Movano?: Yes. We service and repair the Combo and Movano as well as the Vivaro. The Combo is a small van and always Class 4, so we can MOT it here. Most Movanos are plated at 3.5 tonnes and need a Class 7 test elsewhere, but we can service, repair and prepare them.
Will using you affect my Vauxhall warranty?: No. Block exemption rules let an independent garage service your van without affecting the manufacturer warranty, as long as the work follows the schedule and uses parts and oils to the right specification. We do both and record every service.
How do I book my Vivaro in?: Call us on 0121 544 3736 or drop in to 93 Park Lane, Oldbury, B69 4LP. We are open Monday to Friday, 8:30am to 5:30pm. Let us know your registration and what the van is doing, and we will give you a clear quote before we start.

Related services

You may also need

Van Servicing

Van servicing in Oldbury for tradespeople and fleets, to your manufacturer schedule, with a clear quote and a stamped service record.

Find out more

Van Repairs

Van repairs in Oldbury: brakes, clutches, suspension, diesel and electrical faults on all makes, with a clear quote before work starts.

Find out more

Van MOT Testing Oldbury

Class 4 van MOTs in Oldbury for vans up to 3,000kg. Clear results, advisories explained and a quote before any repair.

Find out more

Vauxhall Servicing & Repairs Oldbury

Vauxhall servicing and repairs in Oldbury for Corsa, Astra, Insignia, Mokka and Vivaro — from 1.4 turbo timing chains to 1.2 PureTech wet belts.

Find out more

Clutch replacement

Clutch replacement in Oldbury with diagnosis of slip, bite point issues, and release bearing noise.

Find out more

Areas served

Serving drivers across the local area

We provide vauxhall vivaro servicing & repairs oldbury for customers from across the region — book online or call us.

Experts in vauxhall vivaro servicing & repairs oldbury

Tell us your car and symptoms, we will advise honestly.

Serving Oldbury, West Midlands and surrounding areas towns. Message or call and we will outline likely costs before we book you in.